鸡新城疫病毒LaSota株在BHK-21细胞上增殖条件的优化

doi:10.16431/j.cnki.1671-7236.2019.03.026

摘要/Abstract

摘要：

本研究旨在对鸡新城疫病毒（Newcastle disease virus，NDV） LaSota株在BHK-21细胞上的增殖条件进行优化，为实现应用细胞系生产NDV提供参考。在确定BHK-21细胞TPCK-胰酶耐受浓度的基础上，在培养基中添加不同浓度的TPCK-胰酶、新生牛血清及调节不同pH，通过对细胞培养液细胞半数感染量（TCID₅₀）的测定，确定最适胰酶浓度、血清浓度及pH；通过固定接毒量而添加不同数量细胞或固定细胞数量而接种不同量的病毒，确定最适细胞量及接毒量；将BHK-21细胞接种NDV LaSota株后，通过测定不同时间细胞上清液TCID₅₀绘制增殖曲线，确定最佳收毒时间；应用转瓶对该病毒进行扩大培养，并进行TCID₅₀、鸡胚半数感染量（EID₅₀）与血清凝集价（HA）的测定。结果显示，NDV LaSota株在BHK-21细胞上增殖的最适TPCK-胰酶浓度为3 μg/mL，最适接毒量为10^6.375 EID₅₀，细胞数量为1×10⁶个，培养基pH为7.2，且可用无血清培养基进行培养，BHK-21细胞接种NDV LaSota株后最佳收毒时间为34~36 h。应用BHK-21细胞采用转瓶培养的方式对NDV LaSota株进行增殖，结果显示，细胞培养液TCID₅₀值为10^7.0/0.1 mL，EID₅₀为10^7.5/0.1 mL，HA效价为1：256。因此，应用以上条件增殖培养NDV LaSota株，完全适用于该病毒的规模化生产，且符合现行的兽医生物制品与检验制造规程。

关键词: 新城疫病毒(NDV); LaSota株; BHK-21细胞; 增殖

Abstract:

The aim of this study was to optimize the proliferation conditions of Newcastle disease virus (NDV) LaSota strain on BHK-21 cells,and provide reference for the application of cell line to produce NDV.Firstly,the tolerant concentration of BHK-21 cells to TPCK-trypsin was determined.On this basis,different concentrations of TPCK-pancreatin and newborn bovine serum were added into the medium respectively,and the pH of medium was regulated.The NDV LaSota strain was cultured in the medium and the optimal trypsin concentration,serum concentration and pH of the medium were determined respectively through measuring half-infection amount (TCID₅₀) of the culture.On the other hand,the same quantity of NDV LaSota strain were inoculated to different number of cells or the same number of cells were inoculated by different quantity of virus.The optimal number of BHK-21 cell and the optimal dose of NDV LaSota strain were determined by measuring TCID₅₀.Secondly,the proliferation curve was drawn to determine the optimal time for collection after inoculating the NDV LaSota strain in BHK-21 cells and the TCID₅₀ of the supernatant was determinated at different time.Finally,the NDV LaSota strain was cultured in spinner flask and the TCID₅₀,the half egg infection amount (EID₅₀) and the serum agglutination price (HA) were measured.The results showed that the optimal TPCK-trypsin concentration was 3 μg/mL,the optimal toxic dose was 10^6.375 EID₅₀,the number of cells was 1×10⁶,the pH of the medium was 7.2,and cultured in serum-free medium when the NDV LaSota strain was inoculated in BHK-21 cells.The optimum harvested time was from 34 to 36 h after BHK-21 cells were inoculated with NDV LaSota strain.At the end,the proliferation of NDV LaSota strain was carried out using spinner flask.The results showed that the cell culture solution had a TCID₅₀ value of 10^7.0/0.1 mL,the EID₅₀ was 10^7.5/0.1 mL,and the HA titer was 1∶256.Therefore,the application of the above conditions to culture NDV LaSota strain in BHK-21 cells was fully applicable to the large-scale production of the NDV,and in line with the current veterinary biological products and inspection manufacturing regulations.

Key words: Newcastle disease virus (NDV); LaSota strain; BHK-21 cell; proliferation

中图分类号:

S858.31

董炳梅, 孙培娇, 苗立中, 沈志强, 韩文瑜. 鸡新城疫病毒LaSota株在BHK-21细胞上增殖条件的优化[J]. 《中国畜牧兽医》, 2019, 46(3): 858-864.

DONG Bingmei, SUN Peijiao, MIAO Lizhong, SHEN Zhiqiang, HAN Wenyu. Optimization About Proliferated Condition of Newcastle Disease Virus LaSota Strain in BHK-21 Cells[J]. , 2019, 46(3): 858-864.

参考文献

[1] BROWN JORDAN A,GONGORA V,HARTLEY D,et al.A review of eight high-priority,economically important viral pathogens of poultry within the Caribbean region[J].Veterinary Sciences,2018,5(1):E14.
[2] WANG J Y,LIU W H,REN J J,et al.Characterization of emerging Newcastle disease virus isolates in China[J].Virology Journal,2015,12(119):119.
[3] GANAR K,DAS M,SINHA S.et al.Newcastle disease virus:Current status and our understanding[J].Virus Research,2014,184:71-81.
[4] ALEXANDER D J,ALDOUS E W,FULLER C M,et al.The long view:A selective review of 40 years of Newcastle disease research[J].Avian Pathology,2012,41(4):329-335.
[5] 关平原,申之义,李平安,等.鸡新城疫Ⅰ系疫苗株Vero细胞培养物的免疫试验及Vero细胞的致瘤性检查[J].中国预防兽医学报,1999,21(4):295-297. GUAN P Y,SHEN Z Y,LI P A,et al.Immunity of Newcastle disease vaccine strainⅠcultivated in Vero cell and tumorigenicity of Vero cell to chicken[J].Chinese Journal of Preventive Veterinary Medicine,1999,21(4):295-297.(in Chinese)
[6] 豆艳丽,吴润,刘磊.鸡新城疫病毒感染不同细胞的病变特性研究[J].甘肃农业大学学报,2012,47(4):1-5. DOU Y L,WU R,LIU L.Study on the cytopathic effect properties of Newscastle disease virus addapted to grow in different cell lines[J].Journal of Gansu Agricultural University,2012,47(4):1-5.(in Chinese)
[7] WANG C,CHU Z,LIU W,et al.Newcastle disease virus Ⅴ protein inhibits apoptosis in DF-1 cells by downregulating TXNL1[J]. Veterinary Research,2018,49(1):102-113.
[8] 曲昱蓉,詹媛,仇旭升,等.HeLa细胞中泛素蛋白酶体系统对新城疫病毒复制的影响[J].中国动物传染病学报,2014,22(2):13-19. QU Y R,ZHAN Y,QIU X S,et al.Effect of ubiquitin-proteasome system on Newcastle disease virus replication in HeLa cells[J].Chinese Journal of Animal Infectious Diseases,2014,22(2):13-19.(in Chinese)
[9] ZOU X,ZHU Y,BAO H,et al.Recombination of host cell mRNA with the Asia 1 foot-and-mouth disease virus genome in cell suspension culture[J].Archives of Virology,2019,164(1):41-50.
[10] ROUROU S,BEN AYED Y,TRABELSI K,et al.An animal component free medium that promotes the growth of various animal cell lines for the production of viral vaccines[J].Vaccine,2014,32(24):2767-2776.
[11] 武发菊,刘萍,安芳兰,等.BHK-21悬浮细胞流加培养的研究[J].中国畜牧兽医,2014,41(6):150-153. WU F J,LIU P,AN F L,et al.Study on fed batch of BHK-21 suspension cells[J].China Animal Husbandry & Veterinary Medicine,2014,41(6):150-153.(in Chinese)
[12] 武发菊,刘学荣,尚勇良,等.新城疫疫苗的研究进展[J].中国畜牧兽医,2011,38(10):145-148. WU F J,LIU X R,SHANG Y L,et al.The research progress about Newcastle disease vaccination[J].China Animal Husbandry & Veterinary Medicine,2011,38(10):145-148.(in Chinese)
[13] JANG J,HONG S H,CHOI D,et al.Overexpression of Newcastle disease virus (NDV) Ⅴ protein enhances NDV production kinetics in chicken embryo fibroblasts[J].Applied Microbiology and Biotechnology,2010,85(5):1509-1520.
[14] YURCHENKO K S,ZHOU P,KOVNER A V,et al.Oncolytic effect of wild-type Newcastle disease virus isolates in cancer cell lines in vitro and in vivo on xenograft model[J].PLoS One,2018,13(4):e0195425.
[15] 周晓雅,周祺,殷冬冬,等.鸭坦布苏病毒感染对BHK-21细胞分泌胞外体的影响[J].中国免疫学杂志,2018,34(2):161-166. ZHOU X Y,ZHOU Q,YIN D D,et al.Effect of duck Tembusu virus infection on exosomes of BHK-21 cells[J].Chinese Journal of Immunology,2018,34(2):161-166.(in Chinese)
[16] KIM S H,XIAO S,COLLINS P L,et al.LaSota fusion (F) cleavage motif-mediated fusion activity is affected by other regions of the F protein from different genotype Newcastle disease virus in a chimeric virus:Implication for virulence attenuation[J].The Journal of Genernal Virology,2016,97(6):1297-1303.
[17] RANGASWAMY U S,WANG W,CHENG X,et al.Newcastle disease virus establishes persistent infection in tumor cells in vitro:Contribution of the cleavage site of fusion protein and second sialic acid binding site of hemagglutinin-neuraminidase[J].Journal of Virology,2017,91(16):770-787.
[18] STONE-HULSLANDER J,MORRISON T G.Detection of an interaction between the HN and F proteins in Newcastle disease virus-infected cells[J].Journal of Virology,1997,71(9):6287-6295.
[19] 古长庆,金宁一,金扩世,等.新城疫病毒在不同的细胞上增殖特性的研究[J].黑龙江畜牧兽医,2000,10:5-6. GU C Q,JIN N Y,JIN K S,et al.Study on proliferation characteristics of Newscastle disease virus on the different cells[J].Heilongjiang Animal Science and Veterinary Medicine, 2000,10:5-6.(in Chinese)
[20] 温国元,商雨,郭静,等.新城疫病毒TS09耐热株在BHK细胞上的传代培养[J].湖北农业科学,2012,51(23):5424-5435. WEN G Y,SHANG Y,GUO J,et al.Serial passages culture of Newcastle disease virus thermostable TS09 strain in BHK cells[J].Hubei Agricultural Sciences,2012,51(23):5424-5435.(in Chinese)
[21] GARCIA M.Current and future vaccines and vaccination strategies against infectious laryngotracheitis (ILT) respiratory disease of poultry[J].Veterinary Microbiology,2017,206(10):157-162.
[22] MARTINEZ J C S,CHOU W K,BERGHMAN L R,et al.Evaluation of the effect of live LaSota Newcastle disease virus vaccine as primary immunization on immune development in broilers[J].Poultry Science,2018,97(2):455-462.
[23] SHAHAR E,HADDAS R,GOLDENBERG D,et al.Newcastle disease virus:Is an updated attenuated vaccine needed?[J].Avian Pathology,2018,47(5):1-12.
[24] MAYERS J,MANSFIELD K L,BROWN I H.The role of vaccination in risk mitigation and control of Newcastle disease in poultry[J].Vaccine,2017,35(44):5974-5980.
[25] DIMITROV K M,AFONSO C L,YU Q,et al.Newcastle disease vaccines——A solved problem or a continuous challenge[J].Veterinary Microbiology,2017,206(19):126-136.
[26] 田波,武发菊,安芳兰,等.氨和乳酸对悬浮培养的BHK-21细胞生长和胞内酶活性的影响[J].中国畜牧兽医,2011,38(9):37-40. TIAN B,WU F J,AN F L,et al.The effects of ammonia and lactic acid on suspension culture of BHK-21 cell growth and intracellular enzyme activity[J].China Animal Husbandry & Veterinary Medicine,2011,38(9):37-40.(in Chinese)
[27] PATEL A C,UPMANYU V,RAMASAMY S,et al.Molecular and immunogenic characterization of BHK-21 cell line adapted CVS-11 strain of rabies virus and future prospect in vaccination strategy[J].Virus Disease,2015,26(4):288-296.
[28] 高以明,张敬友,王水明,等.不同动物源新城疫病毒感染不同种属细胞的病变观察[J].中国家禽,2009,31(23):18-21. GAO Y M,ZHANG J Y,WANG S M,et al.Infectivity of NDV from different host to avain embryo fibroblasts or cell lines from mammal animals[J].China Poultry,2009,31(23):18-21.(in Chinese)