1株烟曲霉产耐热纤维素酶发酵条件优化及酶学性质研究

doi:10.16431/j.cnki.1671-7236.2023.11.010

摘要/Abstract

摘要： 【目的】优化1株产耐热纤维素酶烟曲霉的最适产酶条件，分析所产酶液对秸秆的纤维降解效果，为其在纤维素物质生物降解中的应用提供依据。【方法】利用3，5-二硝基水杨酸（DNS）法测定前期研究分离的烟曲霉WL002产纤维素酶的活性，并分析其酶学性质；采用单次单因子法和正交试验对其产酶的培养条件和发酵培养基进行优化；利用体外发酵法分析粗酶对不同粗饲料的纤维降解效果。【结果】酶学性质分析表明，菌株WL002所产纤维素酶的最适反应pH为7.0，pH 6.0~8.0保存0.5和1 h后，残余酶活为74%~95%和56%~90%；最适反应温度为60 ℃，70 ℃保温0.5~1.5 h后，残余酶活为70%~80%。产酶条件优化结果显示，孢子悬液以7%比例接种至含1.0%蛋白胨、2.0%小麦秸秆粉、pH为7.0的发酵培养基，50 ℃培养48 h，菌株WL002所产粗酶的内切葡聚糖酶活性最高，达3.11 U/mL。利用菌株WL002所产粗酶处理小麦秸秆和玉米秸秆60 h，其粗纤维降解率分别为6.1%和4.7%。【结论】烟曲霉WL002菌株所产的纤维素酶具有较宽泛的pH适应性和较强的热耐受性，对饲料粗纤维具有一定的降解能力。本研究初步获得了该菌的最优发酵条件，为其后续开发应用奠定了基础。

关键词: 纤维素酶; 烟曲霉; 酶学性质; 发酵条件优化

Abstract: 【Objective】 The purpose of this experiment was to optimize the optimum enzyme production conditions of a strain of Aspergillus fumigatus producing heat-resistant cellulase, analyze the fiber degradation effect of the enzyme solution on straw, and provide the basis for its application in the biodegradation of cellulose.【Method】 3, 5-dinitrosalicylic acid (DNS) method was used to determine the activities of cellulase produced by Aspergillus fumigatus WL002 from the previous study, and its enzymatic properties were analyzed.The culture conditions and fermentation medium were optimized by the one factor at a time strategy combined with orthogonal test.The crude fiber degradation effects of the crude enzyme on roughage were analyzed by in vitro fermentation.【Result】 Enzymatic characterization analysis revealed that the optimum reaction pH of cellulase produced by WL002 was 7.0, and the residual enzyme activity was 74%-95% and 56%-90% after preservation at pH 6.0-8.0 for 0.5 and 1 h, respectively.The optimal reaction temperature was 60℃, and after holding at 70℃ for 0.5-1.5 h, the residual enzyme activity was 70%-80%.The maximum cellulase production by strain WL002 were achieved with peptone (1.0%) and wheat straw (2.0%) as the best carbon and nitrogen sources, respectively, at pH 7.0, 7% initial inoculum, the incubation time of 48 h and a culture temperature of 50℃, the average cellulase activity reached 3.11 U/mL.The degradation rates of wheat straw and corn straw were 6.1% and 4.7%, respectively, when treated with the crude enzyme produced by strain WL002 for 60 h.【Conclusion】 The cellulase produced by Aspergillus fumigatus WL002 had a wide pH range, strong thermostability and fiber degradability.The proper conditions for producing cellulase of strain WL002 were achieved, which laid a foundation for its follow-up exploitation and application.

Key words: cellulase; Aspergillus fumigatus; enzymatic characteristics; fermentation optimization

中图分类号:

Q814

曹平华, 李晓霞, 李旺, 赵龙妹, 丁轲, 李元晓, 何万领. 1株烟曲霉产耐热纤维素酶发酵条件优化及酶学性质研究[J]. 中国畜牧兽医, 2023, 50(11): 4414-4423.

CAO Pinghua, LI Xiaoxia, LI Wang, ZHAO Longmei, DING Ke, LI Yuanxiao, HE Wanling. Optimization of Fermentation Conditions and Enzymatic Characteristics of the Thermophilic Cellulase from Aspergillus fumigatus[J]. China Animal Husbandry and Veterinary Medicine, 2023, 50(11): 4414-4423.

参考文献

[1] 丛宏斌, 姚宗路, 赵立欣, 等.中国农作物秸秆资源分布及其产业体系与利用路径[J].农业工程学报, 2019, 35(22):132-140. CONG H B, YAO Z L, ZHAO L X, et al.Distribution of crop straw resources and its industrial system and utilization path in China[J]. Transactions of the CSAE, 2019, 35(22):132-140.(in Chinese)
[2] NAIDU Y, SIDDIQUI Y, IDRIS A S.Comprehensive studies on optimization of ligno-hemicellulolytic enzymes by indigenous white rot hymenomycetes under solid-state cultivation using agro-industrial wastes[J].Journal of Environmental Management, 2020, 259:110056.
[3] 张婷, 周睿, 陈雨生.我国饲料粮供需缺口估算研究[J].山东农业科学, 2022, 54(8):158-165. ZHANG T, ZHOU R, CHEN Y S.Estimation of supply-demand gap of feed grain in China[J]. Shandong Agricultural Sciences, 2022, 54(8):158-165.(in Chinese)
[4] 孙润南, 刘晓磊, 崔雪锋.中国近年来畜牧业粗饲料消耗的变化特征及影响[J].饲料研究, 2016, 9:4-9. SUN R N, LIU X L, CUI X F.Characteristics and impacts of roughage consumption in animal husbandry in China[J].Feed Research, 2016, 9:4-9.(in Chinese)
[5] RADEVA G, VALCHEV I, PETRIN S, et al.Comparative kineticanalysis of enzyme hydrolysis of steam-exploded wheat straw[J].Cellulose Chemistry and Technology, 2012, 46(1/2):61-67.
[6] PREMALATHA N, GOPAL N O, JOSE P A, et al.Optimization of cellulase production by Enhydrobacter sp.ACCA2 and its application in biomass saccharification[J].Frontiers in Microbiology, 2015, 6(1046):1-11.
[7] SULYMAN A O, IGUNNU A, MALOMO S O.Isolation, purification and characterization of cellulase produced by Aspergillus niger cultured on Arachis hypogaea shells[J].Heliyon, 2020, 6(12):e05668.
[8] BHARDWAJ N, KUMAR B, AGRAWAL K, et al.Current perspective on production and applications of microbial cellulases:A review[J]. Bioresources and Bioprocessing, 2021, 8:95.
[9] PARRY N J, BEEVER D E, EMYR O, et al.Biochemical characterization and mechanism of action of a thermostable β-glucosidase purified from Thermoascus aurantiacus[J]. Biochemical Journal, 2001, 353(1):117-127.
[10] MA L, LU Y, YAN H, et al.Screening of cellulolytic bacteria from rotten wood of Qinling (China) for biomass degradation and cloning of cellulases from Bacillus methylotrophicus[J].BMC Biotechnology, 2020, 20(1):2.
[11] MANDEEP, LIU H, SHUKLA P.Synthetic biology and biocomputational approaches for improving microbial endoglucanases toward their innovative applications[J].ACS Omega, 2021, 6(9):6055-6063.
[12] KHADKA S, KHADKA D, POUDEL R C, et al.Production optimization and biochemical characterization of cellulase from Geobacillus sp. KP43 isolated from hot spring water of Nepal[J].BioMed Research International, 2022, 2022:6840409.
[13] PATEL A K, SINGHANIA R R, SIM S J, et al.Thermostable cellulases:Current status and perspectives[J].Bioresource Technology, 2019, 279:385-392.
[14] CAO P H, WANG L, WANG Y Y, et al.Alkali-tolerant β-glucosidase produced by newly isolated Aspergillus fumigatus WL002 from rotten wood[J].International Biodeterioration & Biodegradation, 2015, 105:276-282.
[15] 刘东阳.高效纤维素分解菌Aspergillus fumigatus Z5的产酶研究与胞外蛋白组学分析[D].南京:南京农业大学, 2012. LIU D Y.Study on the production of cellulases and comparative secretome analysis in Aspergillus fumigatus Z5[D].Nanjing:Nanjing Agricultural University, 2012.(in Chinese)
[16] 吴秋珏, 张晓庆, 郝正里.用尼龙袋测定饲料中粗纤维的试验研究[J].饲料工业, 2005, 26(1):55-56. WU Q J, ZHANG X Q, HAO Z L.Experimental study on the determination of crude fiber with nylon bag[J].Feed Industry, 2005, 26(1):55-56.(in Chinese)
[17] 朱宁.木质纤维素降解酶系在草本类生物质上的协作机制[D].北京:中国农业大学, 2016. ZHU N.Synergistic mechanism of lignocellulolytic enzyme systems on herbaceous biomass[D].Beijing:China Agriculture University, 2016.(in Chinese)
[18] BHAT M K.Cellulase and their related enzymes in biotechnology[J].Biotechnology Advances, 2000, 18(5):355-383.
[19] KANG S W, PARK Y S, LEE J S, et al.Production of cellulases and hemicellulases by Aspergillus niger KK2 from lignocellulosic biomass[J].Bioresource Technology, 2004, 91(2):153-156.
[20] LIU D Y, ZHANG R F, YANG X M, et al.Thermostable cellulase production of Aspergillus fumigatus Z5 under solid-state fermentation and its application in degradation of agricultural wastes[J].International Biodeterioration & Biodegradation, 2011, 65(5):717-725.
[21] GOMES I, GOMES J, STEINER W.Simultaneous production of high activities of thermostable endoglucanase and β-glucosidase by the wild thermophilic fungus Thermoascus aurantiacus[J].Applied Microbiology and Biotechnology, 2000, 53(4):461-468.
[22] DEHIMAT L, JAOUANI A, CHERFIA R, et al.Optimization of thermostable proteases production under agro-wastes solid-state fermentation by a new thermophilic Mycothermus thermophilus isolated from a hydrothermal spring Hammam Debagh, Algeria[J].Chemosphere, 2022, 286(1):131479.
[23] BADHAN A K, CHADHA B S, SONIA K G, et al.Functionally diverse multiple xylanases of thermophilic fungus Myceliophthora sp.IMI 387099[J]. Enzyme and Microbial Technology, 2004, 35(5):460-466.
[24] PANDEY A, SOCCOL C, RODRIGUEZ-LEON J, et al.Solid-state Fermentation in Biotechnology:Fundamentals and Applications[M].New Delhi:Asiatech Publishers Inc, 2001.
[25] SUKUMARAN R K, SINGHANIA R R, MATHEW G M, et al.Cellulase production using biomass feed stock and its application in lignocellulose saccharification for bio-ethanol production[J].Renewable Energy, 2009, 34(2):421-424.
[26] MAHESWARI D K, JAHAN H, PAUL J, et al.Wheat straw, a potential substrate for cellulase production using Trichoderma reesei[J]. World Journal of Microbiology and Biotechnology, 1993, 9(1):120-121.
[27] ROMERO M D, AGUADO J, GONZÁLEZ L, et al.Cellulase production by Neurospora crassa on wheat straw[J].Enzyme and Microbial Technology, 1999, 25(3-5):244-250.
[28] SAQIB A A N, HASSAN M, KHAN N F, et al.Thermostability of crude endoglucanase from Aspergillus fumigatus grown under solid state fermentation (SSF) and submerged fermentation (SmF)[J].Process Biochemistry, 2010, 45(5):641-646.
[29] MAHMOOD R T, ASAD M J, MEHBOOB N, et al.Production, purification, and characterization of exoglucanase by Aspergillus Fumigatus[J]. Applied Biochemistry and Biotechnology, 2013, 170(4):895-908.
[30] KAUR P P, ARNEJA J S, SINGH J.Enzymic hydrolysis of rice straw by crude cellulase from Trichoderma reesei[J]. Bioresource Technology, 1998, 66(3):267-269.
[31] ŠELO G, PLANINIĆ M, TIŠMA M, et al.A comprehensive review on valorization of agro-food industrial residues by solid-state fermentation[J].Foods, 2021, 10(5):927.
[32] PANDYA J J, GUPTE A.Production of xylanase under solid-state fermentation by Aspergillus tubingensis JP-1 and its application[J]. Bioprocess and Biosystems Engineering, 2012, 35(5):769-779.
[33] SONIA K G, CHADHA B S, SAINI H S.Sorghum straw for xylanase hyperproduction by Thermomyces lanuginosus (D2W3) under solid-state fermentation[J]. Bioresource Technology, 2005, 96(14):1561-1569.
[34] KACHLISHVILI E, PENNINCKX M, TSIKLAURI N, et al.Effect of nitrogen source on lignocellulolytic enzyme production by white-rot basidiomycetes under solid-state cultivation[J].World Journal of Microbiology and Biotechnology, 2006, 22(4):391-397.
[35] SHARADA R, SWATHI K, VENKATESHWAR S, et al.Optimization of cultural conditions for cellulase production by Aspergillus niger (MTCC2196) using submerged fermentation[J].Biosciences Biotechnology Research Asia, 2009, 6(1):289-292.
[36] QURESHI A S, BHUTTO M A, CHIST Y, et al.Production of pectinase by Bacillus subtilis EFRL 01 in a date syrup medium[J].African Journal of Biotechnology, 2012, 11:12563-12570.
[37] KRISHNA C.Production of bacterial cellulases by solid state bioprocessing of banana wastes[J].Bioresource Technology, 1999, 69(3):231-239.
[38] RAJOKA M I, KHAN S, LATIF F, et al.Influence of carbon and nitrogen sources and temperature on hyperproduction of a thermotolerant betaglucosidase from synthetic medium by Kluyveromyces marxianus[J]. Applied Journal of Biochemistry and Biotechnology, 2004, 117(2):75-92.
[39] CHUNDAKKADU K.Solid state fermentation system-An overview[J].Critical Reviews in Biotechnology, 2005, 25(1-2):1-30.
[40] NARASIMHA G, SRIDEVI A, BUDDOLLA V, et al.Nutrient effects on production of cellulolytic enzymes by Aspergillus niger[J].African Journal of Biotechnology, 2006, 5(5):472-476.
[41] ZHOU J, WANG Y H, CHU J, et al.Identification and purification of the main components of cellulases from a mutant strain of Trichoderma viride T 100-14[J].Bioresource Technology, 2008, 99(15):6826-6833.
[42] SWEENEY M D, XU F.Biomass converting enzymes as industrial biocatalysts for fuels and chemicals:Recent developments[J]. Catalysts, 2012, 2(2):244-263.
[43] JIANG X D, GENG A L, HE N, et al.New isolate of Trichoderma viride strain for enhanced cellulolytic enzyme complex production[J]. Journal of Bioscience and Bioengineering, 2011, 111(2):121-127.
[44] INFANZÓN-RODRÍGUEZ M I, RAGAZZO-SÁNCHEZ J A, DEL MORAL S, et al.Enzymatic hydrolysis of lignocellulosic biomass using native cellulase produced by Aspergillus niger ITV02 under liquid state fermentation[J].Biotechnology and Applied Biochemistry, 2022, 69(1):198-208.