不同菌种组合对固态发酵料中营养活性物质含量及体外消化率的影响

doi:10.16431/j.cnki.1671-7236.2015.08.016

摘要/Abstract

摘要： 本试验旨在研究不同菌种组合对固态发酵料中营养活性物质含量及体外消化率的影响。以麸皮、玉米皮、玉米粉、米糠等为固态发酵培养基,将酿酒酵母菌(BC、XR4)与枯草芽孢杆菌(A15)按不同比例组合接种于固态发酵培养基中,其中试验1组以1:1比例接种BC和XR4;试验2组以1:1:0.5比例接种BC、XR4和A15;以不接菌种的培养基为对照组。通过测定发酵底物中5种营养活性物质(β-葡聚糖、甘露聚糖、多肽、氨基酸和有机酸)含量及干物质、粗蛋白质、中性洗涤纤维和酸性洗涤纤维体外消化率来评价不同菌种组合对固态发酵料品质的影响。结果表明:①各组固态发酵料中营养活性物质含量均随着发酵时间的延长而呈不同程度升高,其中以试验2组发酵效果最优,与发酵前相比,试验2组β-葡聚糖、甘露聚糖、多肽、总氨基酸、总有机酸含量分别提高了27.69%、44.72%、27.62%、9.01%、474.99%;②试验1、2组粗蛋白质、中性洗涤纤维和酸性洗涤纤维体外消化率均显著高于对照组(P< 0.05),与对照组相比,试验1、2组干物质、粗蛋白质、中性洗涤纤维和酸性洗涤纤维体外消化率分别提高了0.15%和4.44%、3.29%和4.43%、10.37%和23.00%、33.04%和131.59%,其中试验2组优于试验1组。由此可知,在酿酒酵母菌(BC、XR4)的基础上添加枯草芽孢杆菌(A15)其发酵效果最好,不仅可显著提高产物的营养活性物质含量,也可显著提高其体外消化率。

关键词: 复合菌; 营养活性物质; 体外消化率; 固态发酵

Abstract: The experiment was designed to study the effect of different strain combination on the nutricines content and in vitro digestibility of solid state fermentation material.In this experiment, the solid state fermentation media included wheat bran, corn bran, corn meal, rice bran, etc.The Saccharomyces cerevisiae (BC, XR4) and Bacillus subtilis (A15) were inoculated on the solid state fermentation media in different proportion combination.Group 1 was inoculated with BC and XR4, with a ratio of 1:1 and group 2 was inoculated with BC, XR4 and A15, with a ratio of 1:1:0.5.While the control group was without strains.By measuring the content of 5 nutricines (β-glucan, mannan, peptides, amino acid and organic acid) and in vitro digestibility of DM, CP, NDF and ADF in fermentation substrate to evaluate the effect of different strain combinations on solid state fermentation quality.The results showed as follows:① The nutricines content of 3 groups increased with the extension of fermentation time.Among them, the group 2 had an optimal fermentation effect, compared with the pre-fermentation, the contents of β-glucan, mannan, peptides, total amino acid, total organic acid were increased by 27.69%, 44.72%, 27.62%, 9.01% and 474.99%, respectively.② In vitro digestibility of CP, NDF and ADF in groups 1 and 2 were significantly higher than that in control group (P< 0.05), compared with the control group, the in vitro digestibility of DM, CP, NDF and ADF in groups 1 and 2 were increased by 0.15% and 4.44%, 3.29% and 4.43%, 10.37% and 23.00%, 33.04% and 131.59%, respectively.Group 2 was better than group 1.Thus, on the basis of Saccharomyces cerevisiae (BC and XR4), adding Bacillus subtilis (A15) would bring best fermentation and it not only could significantly improve the nutricines content, but also could significantly increase its in vitro digestibility.

Key words: composite bacteria; nutricines; in vitro digestibility; solid state fermentation

中图分类号:

S816

张锦玲, 王勇, 郭鹏, 张立明, 刘大程. 不同菌种组合对固态发酵料中营养活性物质含量及体外消化率的影响[J]. , 2015, 42(8): 2028-2035.

ZHANG Jin-ling, WANG Yong, GUO Peng, ZHANG Li-ming, LIU Da-cheng. Effect of Different Strain Combination on the Nutricines Contents and in vitro Digestibility of Solid State Fermentation Material[J]. , 2015, 42(8): 2028-2035.

参考文献

[1] 高妍.我国对微生物发酵饲料的研究与应用[J].畜牧与兽医,2013,45(11):93-95.
[2] 陈贵才,戴德慧,黄光荣,等.多菌种发酵餐饮废弃物生产蛋白饲料研究[J].浙江大学学报,2007,33(4):429-434.
[3] 王颖,何宁,李清彪,等.酿酒酵母S.cerevisiea高密度培养条件优化研究[J].工业微生物,2007,37(1):34-38.
[4] 陆熹,李霞,仲小兰,等.微生物发酵在我国饲料工业中的应用及发展探讨[J].现代科技农业,2008,42(1):156-160.
[5] 吴宝昌.枯草芽孢杆菌混合发酵制备豆粕饲料的研究[D].济南:山东轻工业学院,2010.
[6] 卢洪栋,彭爱娟,徐志旭.复合菌固态发酵高蛋白饲料添加剂条件的优化[J].郑州牧业工程高等专科学校学报,2009,29(2):3-6.
[7] 安晓萍,王哲奇,齐景伟,等.混菌固态发酵对豆粕营养特性的影响[J].饲料研究,2014,1:66-70.
[8] 曹香林,陈建军.混菌固态发酵麸皮条件优化及离体消化研究[J].中国畜牧兽医,2014,41(4):123-127.
[9] 刘国娟,刘大程,卢春芳,等.复合菌固态发酵培养基及发酵工艺的优化[J].动物营养学报,2014,26(4):1019-1027.
[10] 卢春芳,刘国娟,刘大程,等.6株酵母菌产营养活性物质能力的比较分析[J].动物营养学报,2014,26(2):533-540.
[11] 中华人民共和国卫生部,中国国家标准化管理委员会.GB/T 5009.124—2003 食品中氨基酸的测定[S].北京:中国标准出版社,2003.
[12] 中华人民共和国卫生部,中国国家标准化管理委员会.GB/T 5009.157—2003 食品中有机酸的测定[S].北京:中国标准出版社,2003.
[13] Menke K H,Steingass H.Estimation of the energetic feed value obtained from chemical analysis and in vitro gas production using rumen fluid[J].Animal Research Development,1988,28(1):7-55.
[14] 李满双,薛树媛,郭天龙,等.贮藏时间对沙柳混合发酵饲料营养成分及体外消化率的影响[J].动物营养学报,2015,27(2):655-662.
[15] 郭鹏举,高巍.反刍动物小肽营养的研究进展[J].中国饲料,2009,6:12-15.
[16] Carro M D,Ranilla M J.Effect of the addition of malate on in vitro rumen fermentation of cereal grains[J].British Journal Nutrition,2003,89:181-188.
[17] 苑文珠,刘建新,吴月明.日粮中直接添加微生物制剂(DFM)对反刍动物的影响[J].饲料研究,2001,2:1-3.
[18] Schingoethe D J,Linke K N,Kalscheur K F,et al.Feed efficiency of mid-lactation dairy cows fed yeast culture during summer[J].Journal of Dairy Science,2004,87(12):4178-4181.
[19] 胡奎娟,吴克,潘仁瑞,等.固态混合发酵提高木聚糖酶和纤维素酶活力的研究[J].菌物学报,2007,26(2):273-278.
[20] 胡瑞,陈艳,王之盛,等.复合益生菌发酵豆粕生产工艺参数的优化及酶菌联合发酵对豆粕品质的影响[J].动物营养学报,2013,25(8):1896-1903.
[21] 姚勇芳,赵祥杰,廖延智,等.陈香茶菌及枯草芽孢杆菌复合发酵豆粕的研究[J].动物营养学报,2014,26(11):3537-3544.
[22] 刘晓艳,杨国力,国立东,等.混菌固态发酵法生产大豆多肽饲料的研究[J].饲料工业,2012,33(6):51-56.
[23] Henry R J.Pentosan and (1-3,1-4)-β-glucan concentrations in endosperm and wholegrain of wheat,barley,oats and rye[J].Journal of Cereal Science,1987,6(3):253-258.
[24] Vinkx C J A,Delcour J A.Rye (Secale cereale L.) arabinoxylans:A critical review[J].Journal of Cereal Science,1996,24(1):1-14.
[25] Saulnier L,Sado P E,Branlard G,et al.Wheat arabinoxylans:Exploiting variation in amount and composition to develop enhanced varieties[J].Journal of Cereal Science,2007,46(3):261-281.
[26] Hollmann J,Elbegzaya N,Pawelzik E,et al.Isolation and characterization of glucuronoarabinoxylans from wheat bran obtained by classical and ultrasound-assisted extraction methods[J].Quality Assurance and Safety of Crops and Foods,2009,1(4):231-239.
[27] 黄燕华.不同来源纤维素酶在肉鹅高纤维日粮中的应用及其作用机理的研究[D].广州:华南农业大学,2004.
[28] 王永花,高峰,周宏光.非淀粉多糖酶制剂在畜禽肠道的作用模式[J].畜牧与兽医,2006,38(9):52-55.
[29] Manners D J,Masson A J,Patterson J C.The structure of β-(1,3)-D-glucan from yeast cell walls[J].Biochemical Journal,1973,135:19-30.
[30] Presta M,Leali D,Stabile H,et al.Heparin derivatives as angiogenesis inhibitors[J].Current Pharmaceutical Design,2003,9(7):553-566.
[31] Lipke P N,Ovalle R.Cell wall architecture in yeast:New structure and new challenges[J].Journal of Bacteriology,1998,180(15):3735-3740.
[32] 王传槐,卞菁.提高酵母饲料质量与作用效率的研究[J].饲料研究,1995,5:6-9.
[33] 伏慧明,华绍烽,杜建中,等.生物饲料添加剂的开发与应用[J].饲料研究,2003,5:57-59.
[34] 潘宝海,李德发,谯仕彦.益生菌、益生素及合生剂的作用机理和相互关系[J].中国饲料,2000,15:12-14.
[35] 王丽娟,孙满吉.饲料酵母及培养物的作用激励机制研究进展[J].粮食与饲料工业,2005,4:112-114.
[36] 邱雪兴,骆宏机,刘文聪.芽孢杆菌在动物营养与饲料中的应用[J].中国畜牧兽医文摘,2014,30(5):194-195.