超声改善氨化稻秸纤维结构工艺优化及其对瘤胃降解特性的影响

doi:10.16431/j.cnki.1671-7236.2020.07.008

摘要/Abstract

摘要： 试验旨在研究超声改善氨化稻秸纤维结构工艺优化及其对瘤胃降解特性的影响。采用响应面设计优化氨化稻秸纤维的超声水平，以中性洗涤纤维（NDF）、酸性洗涤纤维（ADF）和酸性洗涤木质素（ADL）含量为响应值建立多元二次回归数学模型，得到最佳超声水平，并测定最佳超声水平下氨化稻秸与未处理氨化稻秸中营养成分的含量。利用尼龙袋法测定上述样品在奶牛瘤胃中干物质（DM）、NDF及ADF的降解率，得到各营养成分的动态降解参数。结果显示，氨化稻秸的最佳超声水平为超声功率112 W，超声时间17.3 min，液固比10.7：1，容器内声功率密度1.317 W/mL，在此超声水平下的氨化稻秸ADF和ADL含量的最小值分别为43.75%、7.95%，显著低于超声前（P<0.05），实际结果与模型预测接近，说明该模型可行。与超声前相比，氨化稻秸ADF降低了6.64%，ADL降低了11.38%。在瘤胃降解试验中，超声处理后的氨化稻秸DM、NDF、ADF的慢速降解部分（b）、潜在降解部分（d）和有效降解率（ED）均得到极显著提高（P<0.01），其中DM、NDF和ADF的慢速降解部分分别提高了36.52%、30.06%和22.19%，潜在降解部分分别提高了27.15%、28.56%和21.35%，有效降解率分别提高了25.09%、24.98%和24.00%。综上所述，适宜的超声处理可以降低氨化稻秸中ADF和ADL的含量，提高有效降解率。

关键词: 超声处理; 氨化稻秸; 纤维结构; 工艺优化; 瘤胃降解特性

Abstract: The objective of this study was to investigate the optimization of ultrasonic to improve the fiber structure of ammoniated rice straw and its effect on rumen degradation characteristics.The response surface analysis of four factors and five levels of central composite was used to design and optimize the ammoniated rice straw fiber modified ultrasonic conditions.Based on the neutral detergent fiber (NDF),acid detergent fiber (ADF) and acid detergent lignin (ADL) content as response values,a multivariate quadratic regression mathematical model was established to obtain the best ultrasound level.The contents of nutrients in ammoniated rice straw under the optimal ultrasonic level and untreated ammoniated rice straw were determined.The degradation rates of dry matter (DM),NDF and ADF in the rumen of cows were determined by nylon bag method,and the dynamic degradation parameters of each nutrient component were obtained.The results showed that ultrasonic power was 112 W,ultrasonic time was 17.3 min,liquid-solid ratio was 10.7 to 1,and ultrasonic power density was 1.317 W/mL,which was the best ultrasonic condition for ammoniating straw.At this ultrasonic level,the minimum contents of ADF and ADL of ammoniated rice straw were 43.75% and 7.95%,respectively,which were significantly lower than those before ultrasonic (P<0.05).The actual results were close to the model prediction,indicating that the model was feasible.Compared with before ultrasound,ammoniated rice straw ADF decreased by 6.64% and ADL decreased by 11.38%.After ultrasonic treatment,the slow degradation part (b),potential degradation part (d) and effective degradation rate (ED) of DM,NDF,ADF of the ammoniated rice straw were significantly improved (P<0.01),the slow degradation parts of which increased by 36.52%,30.06% and 22.19%,respectively,the potential degradation parts increased by 27.15%,28.56% and 21.35%,respectively,and the effective degradation rates increased by 25.09%,24.98% and 24.00%,respectively.In conclusion,appropriate ultrasonic treatment could reduce the content of ADF and ADL in the ammoniated rice straw and improve the effective degradation rate.

Key words: ultrasonic treatment; ammoniated rice straw; fiber structure; optimization; rumen degradation characteristics

中图分类号:

O426.9

郑健, 杨金山, 房新鹏, 赵洪波, 张永根. 超声改善氨化稻秸纤维结构工艺优化及其对瘤胃降解特性的影响[J]. 中国畜牧兽医, 2020, 47(7): 2033-2042.

ZHENG Jian, YANG Jinshan, FANG Xinpeng, ZHAO Hongbo, ZHANG Yonggen. The Optimization of Ultrasonic to Improve the Fiber Structure of Ammoniated Rice Straw and Its Effect on Rumen Degradation Characteristics[J]. China Animal Husbandry and Veterinary Medicine, 2020, 47(7): 2033-2042.

参考文献

[1] 覃诚.中国秸秆禁烧管理与美国秸秆计划焚烧管理比较研究[D].北京:中国农业科学院,2019. QIN C.A comparative study of crop residue burning ban management in China and crop residue control burning management in the United States[D].Beijing:Chinese Academy of Agricultural Sciences,2019.(in Chinese)
[2] SAMKLONG C,CONE J W,PELLIKAAN W,et al.Utilization of rice straw and different treatments to improve its feed value for ruminants:A review[J].Asian Australasian Journal of Animal Sciences,2010,23(5):680-692.
[3] 王亚静,毕于运,高春雨.中国秸秆资源可收集利用量及其适宜性评价[J].中国农业科学,2010,43(9):1852-1859. WANG Y J,BI Y Y,GAO C Y.Collectable amounts and suitability availability of straw resources in China[J].Scientia Agricultural Sinica,2010,43(9):1852-1859.(in Chinese)
[4] 刘凯玉.不同方法处理稻秸对瘤胃降解及其体外甲烷产生量的影响[D].哈尔滨:东北农业大学,2014. LIU K Y.Effects of treating rice straw with different methods on rumen degradation charateristics and in vitro methane production[D].Harbin:Northeast Agricultural University,2014.(in Chinese)
[5] LI B,CHEN K J,GAO X,et al.Influence of steam explosion on rice straw fiber content[J].Journal of Biobased Materials and Bioenergy,2015,9(6):596-608.
[6] LI B,CHEN K J,GAO X,et al.The use of steam explosion to increase the nutrition available from rice straw[J].Biotechnology and Applied Biochemistry,2015,62(6):823-832.
[7] 沈维政,屈腾宇,魏晓莉,等.超声碱化改善玉米秸秆纤维结构参数优化设计与分析[J].浙江大学学报(农业与生命科学版),2018,44(1):116-124. SHEN W Z,QU T Y,WEI X L,et al.Design and analysis of parameters optimization on development of corn straw fiber composition by ultrasound with alkalization pretreatment[J].Journal of Zhejiang University (Agriculture and Life Sciences Edition),2018,44(1):116-124.(in Chinese)
[8] 王华,许红霞,周大云,等.棉花秸秆超声波碱预处理研究[J].农业环境科学学报,2013,32(2):400-406. WANG H,XU H X,ZHOU D Y,et al.Study on ultrasonic-assisted alkali pretreatment on cotton stalk[J].Journal of Agro-Environmental Science,2013,32(2):400-406.(in Chinese)
[9] 陈明凤.纤维素的去结晶[D].广州:华南理工大学,2011. CHEN M F.Decrystallization of cellulose[D].Guangzhou:South China University of Technology,2011.(in Chinese)
[10] CHUNDAWAT S P S,VISMEH R,SHARMA L N,et al.Multifaceted characterization of cell wall decomposition products formed during ammonia fiber expansion (AFEX) and dilute acid based pre-treatments[J].Bioresource Technology,2010,101(21):8429-8438.
[11] SUN S N,C AO X F,XU F,et al.Structure and thermal property of alkaline hemicelluloses from steam exploded Phyllostachys pubescens[J].Carbohydrate Polymers,2014,101:1191-1197.
[12] AOAC INTERNATIONA.Official Methods of Analysis[S].18th Edition.Arlington,Va,USA,Association of Analytical Chemist,2005.
[13] VAN SOEST P J,ROBERTSON J B,LEWIS B A.Methods for dietary fiber,neutral detergent fiber,and nonstarch polysaccharides in relation to animal nutrition[J].Journal of Dairy Science,1991,74(10):3583-3597.
[14] 文奇男.不同添加剂对水稻秸青贮品质及奶牛生产性能的影响[D].哈尔滨:东北农业大学,2011. WEN Q N.The effect of different additives on fermentation quality of rice straw silage and dairy cattle production[D].Harbin:Northeast Agricultural University,2011.(in Chinese)
[15] 姜鑫,张立阳,赵雪娇,等.发酵玉米蛋白粉对奶牛瘤胃体外发酵特性及微生物菌群的影响[J].中国畜牧兽医,2018,45(4):905-915. JIANG X,ZHANG L Y,ZHAO X J,et al.Effects of fermented corn gluten meal on in vitro fermentation characteristics and microorganism population[J].China Animal Husbandry & Veterinary Medicine,2008,45(4):905-915.(in Chinese)
[16] 李昕,徐宏建,王楠,等.不同热处理豆渣中蛋白质分子结构与其营养价值及瘤胃降解特性的相关性研究[J].动物营养学报,2019,31(1):395-408. LI X,XU H J,WANG N,et al.Correlation of protein molecular structure,its nutritional value and rumen degradation characteristics in different heat treatment okara[J].Chinese Journal of Animal Nutrition,2019,31(1):395-408.(in Chinese)
[17] 赵雪娇,郑健,么恩悦,等.大型青贮窖内不同深度全株玉米青贮质量的比较[J].动物营养学报,2019,31(1):409-417. ZHAO X J,ZHENG J,YAO E Y,et al.Comparison on quality of whole plant corn silage at different depths of large-scale silage silos[J].Chinese Journal of Animal Nutrition,2019,31(1):409-417.(in Chinese)
[18] ØRSKOV E R,MCDONALD I.The estimation of protein degradability in the rumen from incubation measurements weighted according to rate of passage[J].The Journal of Agricultural Science,1979,92(2):499-503.(in Chinese)
[19] 赵连生,牛俊丽,徐元君,等.6种饲料原料瘤胃降解特性和瘤胃非降解蛋白质的小肠消化率[J].动物营养学报,2017,29(6):2038-2046. ZHAO L S,NIU J L,XU Y J,et al.Rumen degradation characteristics of small intestinal digestibility of rumen undegradable protein of six feed ingredients[J].Chinese Journal of Animal Nutrition,2017,29(6):2038-2046.(in Chinese)
[20] 王文骏.柑橘皮果胶超声辅助提取的作用机制研究[D].杭州:浙江大学,2018. WANG W J.The research on the mechanism of ultrasonic-assisted extraction of pectin from citrus peel[D].Hangzhou:Zhejiang University,2018.(in Chinese)
[21] 肖琼,姚春才,勇强,等.玉米秸秆超声辅助酶水解[J].南京林业大学学报(自然科学版),2007,31(4):85-88. XIAO Q,YAO C C,YONG Q,et al.Study on ultrasound assisted enzymatic hydrolysis of corn stover[J].Journal of Nanjing Forestry University (Natural Science Edition),2007,31(4):85-88.(in Chinese)
[22] SUBHEADAR P B,GOGATE P R.Alkaline and ultrasound assisted alkaline pretreatment for intensification of delignification process from sustainable raw-material[J].Ultrasonics Sonochemistry,2014,21(1):216-225.
[23] 唐爱民.超声波作用下纤维素纤维结构与性质的研究[D].广州:华南理工大学,2000. TANG A M.The structure and properties of cellulose fibers treated with ultrasonic wave[D].Guangzhou:South China University of Technology,2000.(in Chinese)
[24] 王永忠,冉尧,陈蓉,等.不同预处理方法对稻草秸秆固态酶解特性的影响[J].农业工程学报,2013,29(1):225-231. WANG Y Z,RAN Y,CHEN R,et al.Effects of different pretreatment methods on enzymatic characteristics of straw straws stalk in solid state[J].Transactions of the Chinese Society of Agricultural Engineering,2013,29(1):225-231.(in Chinese)
[25] 李荣斌,董绪燕,魏芳,等.微波预处理超声辅助酶解大豆秸秆条件优化[J].中国农学通报,2009,25(19):314-318. LI R B,DONG X Y,WEI F,et al.Optimization of straw under the condition of microwave pretreatment and ultrasound-assisted[J].Chinese Agricultural Science Bulletin,2009,25(19):314-318.(in Chinese)
[26] 黄六容,陈甜,赵匀淑,等.超声波改善大蒜秸秆不溶性膳食纤维结构及吸附性[J].农业工程学报,2018,34(12):294-299. HUANG L R,CHEN T,ZHAO Y S,et al.Improvement on structure and insoluble dietary fiber structure from garlic straw induced by ultrasonic[J].Transactions of the Chinese Society of Agricultural Engineering,2008,34(12):294-299.(in Chinese)
[27] 连子如,于海琴,孙慧德,等.焦化废水深度回用中粉末活性炭的超声波再生[J].环境工程学报,2015,9(7):3269-3274. LIAN Z R,YU H Q,SUN H D,et al.Regeneration of activated carbon in coking wastewater advanced treatment by ultrasound[J].Chinese Journal of Environmental Engineering,2015,9(7):3269-3274.(in Chinese)
[28] YAN Q.Acid-ultrasound strengthened alkali pretreatment of rice straw and corncob[J].Journal of Southeast University,2013,43(1):105-109.
[29] 吴兆鹏,谭文兴,蚁细苗,等.甘蔗渣的饲用价值及其作为饲料应用的研究进展[J].中国牛业科学,2016,42(5):41-45. WU Z P,TAN W X,YI X M,et al.The research progress on the feed forage value of bagasse and its application[J].China Cattle Science,2016,42(5):41-45.(in Chinese)
[30] YUAN T Q,YOU T T,WANG W,et al.Synergistic benefits of ionic liquid and alkaline pretreatments of poplar wood.Part 2:Characterization of lignin and hemicelluloses[J].Bioresource Technology,2013,136:345-350.
[31] 向天勇,袁小利,程辉彩,等.低强度间歇超声处理对水稻秸秆厌氧发酵的影响[J].浙江科技学院学报,2019,31(3):192-197. XIANG T Y,YUAN X L,CHENG X C,et al.Effects of low intensity intermittent ultrasonic treatment on anaerobic fermentation of rice straw[J].Journal of Zhejiang University of Science and Technology,2019,31(3):192-197.(in Chinese)